JUNE 2010 -- GM is recalling certain model year 2006-2009 Buick, Lucerne; Cadillac DTS; Hummer H2; Model Year 2008-2009 Buick Enclave; Cadillac CTS; Model Year 2007-2009 Cadillac Escalade, Escalade ESV, Escalade EXT; Chevrolet Avalanche, Silverado, Suburban, Tahoe; GMC Acadia, Sierra, Yukon, Yukon Xl; Saturn Outlook; and Model Year 2009 Chevrolet Traverse vehicles equipped with a heated washer fluid system (HWFS). A recall was implemented in 2008 to add a fuse to the control circuit harness to address the potential consequences of a printed circuit board (PCB) electrical short. However, there have been new reports of thermal incidents on HWFS modules after this improvement was installed. These incidents resulted from a new failure mode attributed to the device's thermal protection feature. The significance varies from minor distortion to considerable melting of the plastic around the HWFS fluid chamber. It is possible for the heated washer module to ignite and a fire may occur. Dealers will permanently disable and remove the heated washer fluid module. An updated page for the owner manual will be provided and inserted in the owner manual to document that the feature has been permanently disabled and removed from the vehicle. The safety recall began on June 11, 2010.   10V-240

NEWS:   GM recalling 1.5M vehicles over fire concerns

YAHOO NEWS – June 8, 2010 – General Motors Co. said Tuesday it was recalling about 1.5 million vehicles worldwide to address a problem with a heated windshield wiper fluid system that could lead to a fire, its second recall over the issue in two years.

The recall affects several pickup trucks, sport utility vehicles, crossovers and passenger car models from the 2006 to 2009 model years. GM conducted a similar recall in 2008 but came across new reports of fires in vehicles that had been fixed.

GM said it would disable the heated washer fluid system module that could lead to fires. The Detroit automaker will pay owners and those leasing vehicles $100 each since the feature is being disabled.

GM said it was aware of five fires but there had been no injuries or crashes reported. Nearly 1.4 million vehicles are in the U.S. and more than 100,000 vehicles are in Canada, Mexico and other international markets.

"While our analysis shows the number of incidents is very small compared with the number of vehicles on the road, we want our customers to have complete peace of mind," said Jeff Boyer, GM's executive director of safety.

The recall covers the 2006-2009 model year Buick Lucerne, Cadillac DTS, and Hummer H2; 2008-2009 Buick Enclave and Cadillac CTS; 2007-2009 Cadillac Escalade, Escalade ESV and Escalade EXT; 2007-2009 Chevrolet Avalanche, Silverado, Suburban and Tahoe; 2007-2009 GMC Acadia, Sierra, Yukon and Yukon XL; 2007-2009 Saturn Outlook; and 2009 Chevrolet Traverse.

The auto company said customers will begin to receive recall letters later this month but can contact their dealer to make an appointment to have the heated washer system removed. Dealers will remove the heated washer fluid module and reroute washer fluid hoses.

GM said the technology was available from only one supplier, Microheat Inc., of Farmington Hills, Mich., which went out of business, preventing GM from working with another supplier on an improved design.

GM recalled more than 900,000 vehicles because of the heated washer fluid system in August 2008 because a short circuit on the circuit board could overheat the ground wire. The National Highway Traffic Safety Administration had opened an investigation in February 2008 into 2007 Yukon and Tahoe vehicles over potential engine compartment fires.

The government closed its investigation after the 2008 recall but GM later came across fires in vehicles that had been fixed under the previous recall, prompting the latest safety action.

MORE RECALL INFO

• Buick Enclave
• Buick Lucerne
• Cadillac CTS
• Cadillac DTS
• Cadillac Escalade, ESV and EXT
• Chevrolet Avalanche
• Chevrolet Silverado
• Chevrolet Suburban
• Chevrolet Tahoe
• Chevrolet Traverse
• GMC Acadia
• GMC Sierra
• GMC Yukon and Yukon XL
• Hummer H2
• Saturn Outlook

DECEMBER 2009 - GM is recalling model year 2010 Cadillac DTS vehicles for failing to comply with the requirements of Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims". The tire and loading information label, which lists the proper tire and vehicle loading information, was not installed on the vehicle. In addition, there are two labels affixed to affected vehicles that incorrectly describe them as an incomplete vehicle. One label is the vehicle certification label, which certifies that the vehicle conforms to all applicable U.S. Federal Motor Vehicle Safety, bumper, and theft prevention standards. The second label is the service parts identification label, which lists various components used in the manufacturing of the vehicle. Driving the vehicle with tires that are not properly inflated could result in tire overloading, premature or irregular wear, and/or poor handling increasing the risk of a crash. GM will mail the three correct labels to owners along with installation instructions. Owners may also take the vehicle and the labels to a dealer for installation. This service will be performed free of charge. The safety recall began on December 22, 2009.   09V-480

NEWS:    GM recalls 944,000 vehicles for fire hazard

Recall involves vehicles that are equipped with windshield washer fluid heaters.

NEW YORK (CNNMoney.com) -- August 28, 2008 -- General Motors is recalling 944,000 vehicles, 850,000 of them in the United States, because of the potential for a fire in the vehicles' heated windshield washer fluid system.

A short circuit in the circuit board that controls the system could cause a grounding wire to overheat. That could lead to smoke and the malfunctioning of other electrical components, GM (GM, Fortune 500) said in a letter to the National Highway Traffic Safety Administration (NHTSA). In rare cases, it could cause a fire, GM said.

GM is aware of three fires caused by this problem, two of which were in the company's own test fleet vehicles, GM spokesman Tom Wilkinson said. The company is not aware of any injuries caused by the problem.

The vehicles must be turned on for the short circuit to occur, Wilkinson said, but he could not say whether the washer fluid heating system needed to be in use.

The models listed below, if they're equipped with a heated windshield washer fluid system, are subject to the recall:

• Model year 2006-08 Buick Lucerne sedans and model year 2008 Buick Enclave SUVs.
• Model year 2006-08 Cadillac DTS sedans and model year 2007-08 Cadillac Escalade, Escalade ESV and Escalade EXT SUVs.
• Model year 2007-08 Chevrolet Avalanche and Silverado trucks and Suburban and Tahoe SUVs.
• Model year 2007-08 GMC Acadia, Yukon, and Yukon XL SUVs and Sierra trucks.
• 2008 Saturn Outlook SUVs.

The fluid heating system is a popular option on many of GM's large cars and SUVs, said Wilkinson.

On cold days, the system heats windshield washer fluid before spraying it onto the windshield, where it can melt ice and frost on the windshield.

To fix the problem, dealers will install a fuse that will shut off the system in the event of a short circuit. GM has not yet provided NHTSA with a schedule detailing when owners of affected vehicles will be notified.

MORE RECALL INFORMATION:

• Buick Lucerne
• Buick Enclave
• Cadillac DTS
• Cadillac Escalade
• Chevrolet Avalanche
• Chevrolet Silverado
• Chevrolet Suburban
• Chevrolet Tahoe
• GMC Acadia
• GMC Sierra
• GMC Yukon
• Saturn Outlook

---

AUGUST 2008 -- GM is recalling 857,735 MY 2006-2008 Buick Lucerne; Cadillac DTS; Hummer H2; MY 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT; Chevrolet Avalanche, Silverado, Suburban, Tahoe; GMC Acadia, Sierra, Yukon, Yukon XL, Saturn Outlook; and MY 2008 Buick Enclave vehicles equipped with a heated wiper washer fluid system. A short circuit on the printed circuit board for the washer fluid heater may overheat the control-circuit ground wire. This may cause other electrical features to malfunction, create an odor, or cause smoke increasing the risk of a fire. Dealers will install a wire harness with an in-line fuse free of charge. The manufacturer has not yet provided an owner notification schedule.  08V441