MARCH 2011 -- Volkswagen is recalling certain model year 2011 Jetta vehicles, manufactured from March 2010 through March 2011. These vehicles may have an electrical wiring and fuse layout where the converter box is protected by the same fuse used by the signal horn and the anti-theft alarm system. Should that fuse be blown, the converter box will be disconnected from the power supply which, in turn, will shut off applications such as the engine management system, lighting system, and wipers. Should this happen while the vehicle is being driven, the engine could stall, or the headlights or wipers could turn off unexpectedly, potentially leading to a crash without warning. Volkswagen will notify owners when sufficient quantities of repairs kits are available. Dealers will separate the wiring for the horn and the theft protection horn from the power supply of the converter box and route the wires to separate fuses to correct the condition free of charge. The safety recall is expected to begin during May 2011.    11V-196

NEWS:   VW recalls about 71,000 Jettas for Horn wiring issue

YAHOO NEWS -- March 11,  2011 – Volkswagen AG's U.S. unit recalled more than 71,000 Jetta sedans due to a defect in the wiring system controlling the car horn that can cause the car to stall, a company spokeswoman said on Monday.

The wiring layout that controls the horn also controls the converter box, which governs the engine management system, lighting system and wipers.

In "very rare" circumstances, an electrical short in the horn could cause a short in the converter box and could make the vehicle stall, VW spokeswoman...said.

VW said in a statement that 71,043 Jettas for the model year 2011 are affected by the recall. VW said there have been no reported injuries and accidents related to this defect.

The Jettas were built between March 2010 and March 2011.

MORE RECALL INFO:   Volkswagen Jetta

NEWS:   Volkswagen recalls more than 228,000 cars in US

YAHOO NEWS -- December 15,  2010 –  Volkswagen has recalled more than 228,000 vehicles in the United States amid fears that faults could cause the vehicles' engines to catch fire.

The German carmaker recalled Jetta, Jetta Sportwagen, Golf and Rabbit models manufactured between 2007 and 2009 due to a small plastic tab that could cause a leak in the fuel pipe, The National Highway Traffic Safety Administration (NHTSA) said in a statement.

VW further recalled the New Beetle and New Beetle convertible vehicles equipped with 2.5 liter engines made between 2006 and 2010, which have a clamp in the power steering system that could also pierce the fuel supply line.

"If chafing occurs, there is the potential for a fuel leak to develop. Fuel leakage, in the presence of an ignition source, could result in fire," the NHTSA said.

Some 228,236 cars could be affected by the recall, it said.

MORE RECALL INFO: 

• Volkswagen Jetta
• Volkswagen Golf
• Volkswagen Rabbit

DECEMBER 2010 - Volkswagen is recalling certain model year 2006-2010 Jetta, New Beetle, New Beetle Convertible, model year 2009 Jetta Sportwagen and model year 2007-2009 Rabbit vehicles equipped with 2.5L engines. The Jetta, Jetta Sportwagen, and Rabbit vehicles may have a small plastic tab located on the windshield washer fluid reservoir that may chafe against an underhood fuel supply line. The new beetle and the new beetle convertible vehicles may have a fastening clamp on a hydraulic hose of the power steering system that may be located in an improper position which could cause chafing against an underhood fuel supply line. If chafing occurs, there is the potential for a fuel leak to develop. Fuel leakage, in the presence of an ignition source, could result in a fire. Dealers will inspect and if necessary replace the underhood fuel line. Additionally, depending on the vehicle model, dealers will either remove the plastic tab from the windshield washer fluid reservoir, or inspect the position of the fastening clamp and adjust the related fastening clamp into the correct position. This service will be performed free of charge. The safety recall is expected to begin on or before January 31, 2011 10V-621

AUGUST 2009 -- Volkswagen is recalling certain model year 2009 and 2010 passenger cars manufactured between September 2008 and August 2009. The wiring harness of a temperature sensor in the direct shift gearbox (DSG) may have connector wires that were insufficiently crimped. With insufficiently crimped connector wires, a temperature sensor has the potential to falsely detect a high gearbox oil temperature, causing the transmission to abruptly shift to neutral. If this happens, the selector lever position indicator within the instrument panel will flash. In addition, the "Depress Brake Pedal" indicator light will be illuminated, alerting the driver to apply the brakes. The abrupt shift to neutral could lead to a crash without warning. Volkswagen will notify owners, inspect the DSG and, if necessary, replace an affected DSG temperature sensor free of charge. The manufacturer has not yet provided a notification schedule.  09V-333

NEWS:  VW recalling 13,500 vehicles over transmission

August 20, 2009 -- Yahoo News -- WASHINGTON – Volkswagen of America is recalling 13,500 vehicles to fix problems with a dual-clutch transmission that could lead to a warning on the dashboard.

The recall affects 2009 model year and a limited number of 2010 Jetta, Jetta SportsWagen, GTI and Eos vehicles built between September 2008 and August 2009. Volkswagen says some of the vehicles could have a faulty temperature sensor in the transmission, which could lead to the warning lamp lighting up on the dashboard. They said in rare cases, the transmission could shift into neutral.

           MORE RECALL INFO:

• Jetta
• Jetta SportsWagen
• GTI
• Eos

MAY 2009 --  Volkswagen is recalling 25,594 MY 2006-2009 Jetta 5th generation equipped with 2.01 engine. The fastening screw contact surfaces on the driveshaft cover plate may not have been manufactured to factory specifications.  Some screws may not have been torqued properly during assembly and could loosen over time, causing a knocking sound when the vehicle is in motion. The driveshaft screws could loosen to the point where the driveshaft detaches from the gearbox. If the vehicle is moving when this happens, the detached driveshaft could cause damage the gearbox housing. A damage gearbox housing could leak gearbox oil onto the street and create a risk of a vehicle crash for both the driver and other motorists. Dealers will inspect the driveshaft screws and replace the screws free of charge. The recall is expected to begin on or before June 19, 2009. O  09V-164

SEPTEMBER 2007 -- VW is recalling 340,000 MY 2005-2008 Jetta and MY 2006-2008 Rabbit, GTI, and R32 vehicles for failing to comply with the requirements of Federal Motor Vehicle Safety Standard No. 108, "Lamps, Reflective Devices, and Associated Equipment." Some vehicles may not have had a required cap installed which disables the headlight horizontal aim and some vehicles may contain a cap that disables the vertical aiming screw. Noncompliance can inhibit proper headlamp aim adjustment for roadway illumination. Improperly aimed headlamps could cause reduced road visibility, increasing the risk of a crash. Dealers will inspect for the presence of a cap in the socket of the low beam horizontal aiming screw and install one if missing, and inspect for the presence of a cap in the socket of the vertical aiming screw and if present, the cap will be removed. The recall is expected to begin on or about October 31, 2007. This recall was the subject of an investigation, OA-108-070412I, conducted by the Office of Vehicle Safety Compliance. 07V442

NEWS:   Volkswagen recalls Jetta cars over potential fuel leak

Detroit News -- July 8, 2007 -- Volkswagen AG is recalling 2006 Jetta cars with 2.5-liter gasoline engines in the United States because a tab on the windshield-wiper fluid container can rub against a fuel line, possibly causing a leak and fire, Bloomberg News reported.

The recall will affect about 58,900 cars and will begin in August, the National Highway Traffic Safety Administration said on its Web site. Dealers will remove the plastic tab on the fluid reservoir and, if necessary, replace the fuel line, Volkswagen told the agency, Bloomberg reported.

NEWS:   Volkswagen recalls nearly 800,000 cars

Defective brake lights on Golf, GTI, Jetta, New Beetle and R32 are a potential safety hazard and should be replaced.

February 26, 2007 - NEW YORK (CNNMoney.com) -- Around 800,000 Volkswagen vehicles have been recalled Monday because of faulty brake lights, the National Highway Traffic Safety Administration said.

The 790,000 vehicles include Jettas, New Beetles, Golfs, GTIs and R32s...all in the United States.

The specific years and models affected are:

• 1999-2005 Jetta sedans
• 2001-2005 Jetta wagons
• 1998-2007 New Beetle
• 2003-2007 New Beetle Convertibles
• 1999-2006 Golfs and GTIs
• 2004 R32

The malfunctioning brake lights and brake light switches could fail to come on or remain stuck on.

This recall expands on one announced by Europe's No. 1 carmaker last year, when 362,000 Jettas and New Beetles were recalled due to the same defective part.

Volkswagen said that dealers will immediately be prepared to accept service appointments to perform the repair at no charge, but the notification process isn't scheduled to begin until April.

NHTSA did not say if any injuries had been reported linked to the defective brake lights.

NEWS:   VW recalls 362,000 cars

May 26, 2006,  -- DETROIT (Reuters) - Volkswagen AG is recalling 362,000 cars in the United States because a brake light switch may malfunction, according to U.S. safety regulators.

The models involved include the Jetta sedan from 1999-2002 model years, Jetta III from 1999-2000 model years and the New Beetle from 1998-2002 model years, National Highway Traffic Safety Administration said on its Web site on Friday.

NEWS:   Volkswagen AG will recall 362,000 Jettas and New Beetles

May 26, 2006,  -- Volkswagen AG will recall 362,000 Jettas and New Beetles for brake-light failures, the NHTSA said.

The Volkswagen recall covers 1999 through 2002 Jettas and 1998 through 2002 New Beetles, the agency said. A brake-light switch may not have been properly installed during previous recalls in 2003 and 2004, and the lights either don't work or stay on all the time.

COMMON COMPLAINTS : 

• Check Engine Light on?

• Engine Coil

• Oxygen Sensor